1. Introducció
This manual provides detailed instructions for the assembly, operation, and maintenance of your DUTRIEUX Mercury Magic Board 330 RC Aerobatic Airplane. Designed for both beginner and experienced model enthusiasts, this DIY foam aircraft offers an engaging building experience and exciting aerobatic flight capabilities. Please read this manual thoroughly before assembly and operation to ensure safe and optimal performance.
Disclaimer: Not suitable for children under 36 months due to small parts and potential hazards.
2. Package Contents (KIT Version)
The KIT version of the Mercury Magic Board 330 includes the following components for manual assembly:
- Airplane body (foam parts)
- Regulators (x4)
- Corners (x4)
- Motor seat (x1)
- Magic Belt (for battery, x1)
- Fixing rod (x2)
- Brida de cable (x4)
- Pull rod (x4)
- Magic Belt (for wing, x1)
Note: This KIT version requires additional electronic components (motor, ESC, servos, receiver, flight battery, and remote control) which are NOT included and must be purchased separately for flight. The "PNP" (Plug-N-Play) version, if available, would include these electronics pre-installed.
3. Instruccions de muntatge
The Mercury Magic Board 330 utilizes a card slot assembly method, making it suitable for novice model enthusiasts. The estimated assembly time is approximately 2 hours.
3.1 Passos de l'Assemblea General
- Desempaquetar components: Carefully remove all foam parts and accessories from the packaging.
- Identifica les parts: Familiarize yourself with the main body, wings, tail sections, and smaller components like regulators, corners, and rods.
- Muntatge del cos principal: Begin by slotting together the main fuselage sections. Ensure all connections are secure and aligned.
- Fixació de l'ala: Attach the wings to the main fuselage using the designated card slots. Use the provided fixing rods and magic belts as indicated for reinforcement.
- Tail Section Assembly: Assemble and attach the horizontal and vertical stabilizers (tail rudder and elevator sections) to the rear of the fuselage.
- Enllaços de la superfície de control: Install the pull rods and cable ties to connect the servos (not included in KIT) to the ailerons, elevator, and rudder. Ensure free movement of all control surfaces.
- Motor and Motor Seat Installation: Secure the motor seat to the front of the aircraft. Install a compatible motor (e.g., 2212/2216 series 1000KV) onto the motor seat.
- Electronic Component Installation (for PNP or separately purchased electronics):
- Install the Electronic Speed Controller (ESC) and connect it to the motor and flight battery (not included).
- Install servos for ailerons, elevator, and rudder, connecting them to the pull rods.
- Install the receiver and connect it to the ESC and servos.
- Secure the flight battery using the provided magic belt in the designated compartment.
- Comprovacions finals: Before flight, ensure all parts are securely attached, control surfaces move freely and correctly, and the center of gravity is balanced according to standard RC airplane practices.
4. Instruccions de funcionament
The Mercury Magic Board 330 is designed for outdoor use and offers 3-channel control for aerobatic maneuvers. It is suitable for operators with Beginner, Intermediate, and Expert skill levels.
4.1 Llista de verificació prèvia al vol
- Ensure all electronic components (motor, ESC, servos, receiver, battery) are correctly installed and connected.
- Verify that the flight battery is fully charged and securely fastened.
- Check that the remote control batteries are fresh (Controller Battery: five, likely AA or AAA).
- Perform a range check with your remote control (Remote Distance: 200m).
- Confirm that all control surfaces (ailerons, elevator, rudder) respond correctly to remote control inputs (Controller Mode: MODE2).
- Inspect the aircraft for any damage or loose parts.
- Check weather conditions; the aircraft has an Anti-wind Ability of 4, indicating moderate wind resistance. Avoid flying in strong winds.
4.2 Flight Controls (MODE2)
- Palanca esquerra (accelerador/diró):
- Up/Down: Controls motor thrust (Throttle).
- Left/Right: Controls Tail Rudder for yaw (turning left/right).
- Right Stick (Aileron/Elevator):
- Up/Down: Controls Elevator for pitch (nose up/down, climbing/diving).
- Left/Right: Controls Ailerons for roll (banking left/right).
4.3 Takeoff and Flight
- Find an open, clear outdoor area away from people, obstacles, and power lines.
- With the motor at low throttle, gently hand-launch the aircraft into the wind.
- Gradually increase throttle and use the right stick to maintain level flight.
- Practice basic turns and altitude control before attempting aerobatic maneuvers.
- The typical Flight Time is 10-20 minutes, depending on battery capacity and flight style. Monitor your flight time to avoid unexpected power loss.
4.4 Aterratge
- Approach the landing area into the wind.
- Reduce throttle gradually and maintain a gentle descent using the elevator.
- Aim for a smooth, controlled glide. Just before touchdown, gently pull back on the elevator to flare the aircraft for a soft landing.
- Once on the ground, cut the throttle completely.
5. Manteniment
The Mercury Magic Board 330 is constructed from a durable, drop-resistant magic board foam template, offering good resistance to impacts and moisture. Proper maintenance will extend its lifespan.
5.1 Post-Flight Checks
- Inspect the foam body for any cracks, dents, or tears. Repair with foam-safe glue if necessary.
- Check all control surface hinges and linkages for wear or damage.
- Ensure the motor, propeller, and landing gear (if applicable) are secure and undamaged.
- Disconnect and remove the flight battery. Allow it to cool before recharging.
5.2 Neteja i emmagatzematge
- Wipe down the aircraft with a soft, damp cloth to remove dirt or debris. Avoid harsh chemicals.
- Store the aircraft in a cool, dry place, away from direct sunlight and extreme temperatures, to prevent foam degradation.
- If disassembling for storage, ensure all components are kept together to prevent loss.
6. Solució De Problemes
Aquí teniu alguns problemes comuns i les seves possibles solucions:
| Problema | Causa possible | Solució |
|---|---|---|
| L'avió no respon als controls. |
|
|
| El motor no gira. |
|
|
| Aircraft flies erratically or not straight. |
|
|
7. Especificacions
| Atribut | Valor |
|---|---|
| Nom de marca | DUTRIEUX |
| Nom del model | Mercury Magic Board 330 |
| Tipus | Avió |
| Material | Foam (Drop resistant magic board template) |
| Wingspan Width | Uns 83 cm |
| Longitud del cos | Uns 87 cm |
| Pes corporal | Aproximadament 200 g |
| Color (KIT version) | Blau Negre |
| Mètode de muntatge | Card slot assembly |
| Temps estimat de muntatge | Aproximadament 2 hores |
| Característiques | Drop resistant, folding resistant, waterproof, lightweight |
| Canals de control | 3 canals |
| Mode controlador | MODE 2 |
| Distància Remota | 200 m |
| Temps de vol | 10 ~ 20 minuts |
| Ús interior/exterior | A l'aire lliure |
| Nivell d'habilitat de l'operador | Principiant, Intermedi, Expert |
| Capacitat antivent | 4 (on a scale of 1-6) |
| Edat recomanada | 6-12 anys, 14+ anys |
| Certificació | CE |
| És elèctric | Yes (requires separate electronics, KIT does not include flight battery) |
| S'inclouen les piles? | Yes (likely for remote control, not flight battery) |
| Bateria del controlador | Five (type not specified, typically AA or AAA) |
8. Consells d'usuari
- Comença de manera senzilla: If you're a beginner, practice basic takeoffs, straight flights, and gentle landings in a large, open field before attempting complex aerobatics.
- Wind Awareness: Always check wind conditions. While the plane has moderate wind resistance, calm days are best for learning and precision flying.
- Gestió de la bateria: Invest in multiple flight batteries to extend your flying sessions. Always allow batteries to cool before recharging and store them safely.
- Foam Repair: Keep foam-safe glue handy for quick repairs. Minor crashes are common, and quick fixes can get you back in the air faster.
- Seguretat de l'hèlix: Always be mindful of the spinning propeller. Ensure hands and face are clear during motor operation.
9. Garantia i Suport
For any questions regarding assembly, operation, or troubleshooting that are not covered in this manual, please contact the seller or manufacturer's customer support. Keep your purchase receipt as proof of purchase for any warranty claims.
The manufacturer is committed to providing quality products and support. Please refer to the product listing or contact the seller for specific warranty terms and conditions.
